소개
This instruction manual provides essential information for the proper installation, operation, and maintenance of your American Plumber WDGD-5005 Dual-Gradient Polypropylene Filter Cartridge. Please read this manual thoroughly before installation and retain it for future reference. This filter is designed to reduce sediment, dirt, silt, rust, and scale particles from your water supply.
제품 특징 및 이점
- Dual-Gradient Filtration: Functions as both a pre-filter and a post-filter within a single cartridge, offering efficient multi-stag여과.
- Enhanced Dirt Holding Capacity: Engineered to hold three times the amount of dirt compared to similar wound cartridges, extending filter life.
- 미크론 등급: Features a 50-micron pre-filter for larger particles and a 5-micron post-filter for finer sediment removal.
- 오염물질 감소: Effectively reduces extra-fine sand, dirt, silt, rust, and scale particles from your water.
- 인증된 자재: The WDGD-5005 is tested and certified by NSF International under NSF/ANSI Standard 42 for material requirements only, ensuring product safety and quality.
- 호환성: Designed to fit American Plumber W10-PR and W15-PR whole house filter housings.
Image: Packaging for the American Plumber WDGD-5005 filter cartridge, highlighting its dual-gradient polypropylene construction and sediment reduction capabilities. The packaging also indicates NSF certification for material requirements and compatibility with W10-PR and W15-PR housings.
안전 정보
- Always turn off the main water supply before installing or replacing the filter cartridge.
- Relieve water pressure in the system before opening the filter housing.
- Use appropriate tools for housing removal and tightening to prevent damage or leaks.
- 모든 연결 부분이 안전하게 되어 누출을 방지하세요.
- 시스템 사용 전후에 적절한 소독 없이 미생물학적으로 안전하지 않거나 품질이 알려지지 않은 물과 함께 사용하지 마십시오.
- 이 필터는 냉수 용도로만 설계되었습니다.
설정 및 설치
This filter cartridge is designed for use in compatible whole house filter housings, such as the American Plumber W10-PR and W15-PR models. Refer to your filter housing's manual for specific instructions on opening and closing the housing.
- 물 공급을 차단하세요: 집의 메인 급수 차단 밸브를 찾아 잠그세요.
- 압력 완화: Open a nearby faucet to relieve pressure in the water lines.
- 필터 하우징 개방형: Using the appropriate wrench, unscrew the filter housing sump from the cap.
- 오래된 카트리지 제거: Carefully remove the old filter cartridge and discard it.
- 깨끗한 주택: Clean the inside of the filter housing sump with warm, soapy water. Rinse thoroughly.
- O링을 점검하십시오: Inspect the housing O-ring for any cracks or damage. Replace if necessary. Lubricate the O-ring with a silicone lubricant if recommended by your housing manufacturer.
- 새 카트리지를 삽입하세요: Place the new American Plumber WDGD-5005 filter cartridge into the housing sump. Ensure it is seated properly.
- 주택 재조립: Screw the housing sump back onto the cap, hand-tightening first, then using the wrench for a snug fit. Do not overtighten.
- 물 공급 복구: 주요 물 공급장치를 천천히 켜세요.
- 누출 확인: Monitor the filter housing for any leaks. If leaks occur, turn off the water, relieve pressure, and re-tighten the housing.
- 플러시 시스템: Open a nearby cold water faucet and let the water run for several minutes to flush out any air or fine particles from the new filter.
작동 지침
Once properly installed, the American Plumber WDGD-5005 filter cartridge operates automatically as water flows through your whole house filtration system. It continuously filters sediment and other specified particles from your water supply.
- No special adjustments are required for normal operation.
- Monitor water pressure. A noticeable drop in water pressure may indicate that the filter cartridge is becoming clogged and requires replacement.
유지
필터 카트리지 교체
The filter cartridge life varies depending on usage and water conditions, including the amount of sediment in your water. It is recommended to replace the filter cartridge when you observe a noticeable decrease in water flow or a decline in water quality.
- For optimal performance, replace the filter cartridge every 3 to 6 months, or sooner if water flow significantly diminishes.
- Follow the "Setup and Installation" steps (1-11) to replace the old cartridge with a new American Plumber WDGD-5005 filter.
문제 해결
| 문제 | 가능한 원인 | 해결책 |
|---|---|---|
| 감소된 물 흐름 | 필터 카트리지가 막혔습니다. | 필터 카트리지를 교체하십시오. |
| 주택 누수 | Improperly seated O-ring, damaged O-ring, or loose housing. | Turn off water, relieve pressure, inspect and reseat/replace O-ring, tighten housing. |
| Sediment in Filtered Water | Improperly installed cartridge, damaged cartridge, or filter bypass. | Ensure cartridge is seated correctly. Check for damage. Verify no bypass is active. Replace cartridge if damaged. |
명세서
| 기인하다 | 세부 사항 |
|---|---|
| 모델 번호 | WDGD-5005 |
| 상표 | AP (American Plumber) |
| 재료 | 폴리프로필렌(PP) |
| 제품 치수 | 4인치 깊이 x 4인치 너비 x 10인치 높이 |
| 미크론 등급 | 50-Micron (pre-filter) / 5-Micron (post-filter) |
| 제품 이점 | Removes Impurities, Reduces Sediment, Removes Odor |
| 호환성 | Fits American Plumber W10-PR and W15-PR housings |
| 인증 | NSF/ANSI Standard 42 for material requirements only |
| 한국어: | 726714834372 |
보증 및 지원
For specific warranty information regarding your American Plumber WDGD-5005 filter cartridge, please refer to the documentation provided with your purchase or contact the retailer or manufacturer directly. Warranty terms typically cover manufacturing defects.
For technical support, replacement parts, or further assistance, please contact American Plumber customer service or your authorized dealer. Contact information can usually be found on the product packaging or the manufacturer's official web대지.